I have the NP435 and single speed transfer case in my 67 4x4. Is there a 2 speed transfer case I can upgrade to? I was going to go to a 5 speed, but can't find one that will adapt to my 390 without costing a fortune. So, I'll stick with the NP435 (and maybe have it regeared, if possible), but I'd like to get a 2 speed transfer case. Is there one available for the NP435?
Thanks!
The FORDification.com Forums
The 1967-1972 Ford F-series Pickup Resource
Transfer case upgrade
Moderators: heep70, FORDification
11 posts • Page 1 of 1 [ Previous topic | Next topic ]
Transfer case upgrade
by 67nukeford on Tue Nov 03, 2009 6:40 pm
1967 F100 4WD
Link to project thread:http://www.fordification.com/forum/viewtopic.php?f=7&t=44183
Link to project thread:http://www.fordification.com/forum/viewtopic.php?f=7&t=44183
-
67nukeford - New Member
- Posts: 129
- Joined: Tue Aug 19, 2008 4:20 pm
- Location: Nebraska, Omaha/Elkhorn
Re: Transfer case upgrade
by 67F110 on Tue Nov 03, 2009 8:12 pm
I think the Dana 20 out of an early Bronco with an adapter will work. Do a search in this forum and see what pops up. It's been done.
-
67F110 - New Member
- Posts: 92
- Joined: Fri Oct 09, 2009 5:38 pm
Re: Transfer case upgrade
by cep62 on Tue Nov 03, 2009 8:53 pm
You could also get a NP435 with a 205 gear drive out of a '76-'79.
You'll need the tranny because yours is a 2wd with a adapter.
The D20 would be a good choice and it even has a lower ratio, but it might cost more to covert.?
You'll need the tranny because yours is a 2wd with a adapter.
The D20 would be a good choice and it even has a lower ratio, but it might cost more to covert.?
-
cep62 - Blue Oval Fanatic
- Posts: 806
- Joined: Sun Oct 26, 2008 9:06 pm
- Location: West Michigan
Re: Transfer case upgrade
by 67nukeford on Wed Nov 04, 2009 7:33 pm
Thanks cep, I think that will be the direction I go. I need to find a donor for the power steering anyway, now if I could just find a truck with a good tranny and transfer case to donate with it!
1967 F100 4WD
Link to project thread:http://www.fordification.com/forum/viewtopic.php?f=7&t=44183
Link to project thread:http://www.fordification.com/forum/viewtopic.php?f=7&t=44183
-
67nukeford - New Member
- Posts: 129
- Joined: Tue Aug 19, 2008 4:20 pm
- Location: Nebraska, Omaha/Elkhorn
Re: Transfer case upgrade
by hazelnut on Wed Nov 04, 2009 8:44 pm
the bump F250 4X4s come with 2 speed cases,dana 24s should bolt right in.
-
hazelnut - Blue Oval Fanatic
- Posts: 801
- Joined: Fri Oct 23, 2009 2:06 am
- Location: Williamsburg,Virginia
Re: Transfer case upgrade
by Redcap on Wed Nov 04, 2009 10:04 pm
Divorced or married?
Definitely skip the Dana 24 (piece of crap) and head straight for the NP205, which is available in either version.
Definitely skip the Dana 24 (piece of crap) and head straight for the NP205, which is available in either version.
-
Redcap - 100% FORDified!
- Posts: 2033
- Joined: Mon Dec 20, 2004 11:29 pm
- Location: Washington, Centralia
Re: Transfer case upgrade
by 67nukeford on Thu Nov 05, 2009 10:22 am
Married. I've heard that about the dana also, so I'll stick with the 250.
1967 F100 4WD
Link to project thread:http://www.fordification.com/forum/viewtopic.php?f=7&t=44183
Link to project thread:http://www.fordification.com/forum/viewtopic.php?f=7&t=44183
-
67nukeford - New Member
- Posts: 129
- Joined: Tue Aug 19, 2008 4:20 pm
- Location: Nebraska, Omaha/Elkhorn
Re: Transfer case upgrade
by shaggys_bump on Thu Nov 05, 2009 11:58 pm
viewtopic.php?f=11&t=45460 <<<---- click
1970 F100 Ranger XLT SWB 302
2004 Nissan Murano
1998 Isuzu Amigo "v6 4x4 conversion comin soon"
2004 Nissan Murano
1998 Isuzu Amigo "v6 4x4 conversion comin soon"
-
shaggys_bump - New Member
- Posts: 137
- Joined: Wed Feb 04, 2009 11:36 pm
- Location: Woodruff, South C
Re: Transfer case upgrade
by eggman918 on Sat Dec 05, 2009 2:46 pm
Dana 24, I just rebuilt mine at 750,000 miles, I have nothing bad to say about a 24, but they are getting hard to find. However if you have over 450 hp it would be worth finding a NP205.MY truck has a stout 390 and lives in 4WD . Oh well free advice...... Good luck 
Steve
The"Filthy Beast"- '68 F-250 Crew Cab 131"W/B 4x4 4BT/M5R2/dana 24TC /4.10 44 front/60 rear. 2nd owner
"Beauty is only skin deep....Ugly is to the bone"
It is more important to understand what you don't know than what you do know,because then you can start to learn..???
"you must deal with the attaboys and the ass chewing s with your head up and looking them in the eyes" T.J.E. aka My Dad
There are only three types of people wolfs, sheepdogs, and sheep. What are you?
The"Filthy Beast"- '68 F-250 Crew Cab 131"W/B 4x4 4BT/M5R2/dana 24TC /4.10 44 front/60 rear. 2nd owner
"Beauty is only skin deep....Ugly is to the bone"
It is more important to understand what you don't know than what you do know,because then you can start to learn..???
"you must deal with the attaboys and the ass chewing s with your head up and looking them in the eyes" T.J.E. aka My Dad
There are only three types of people wolfs, sheepdogs, and sheep. What are you?
-
eggman918 - Blue Oval Fan
- Posts: 516
- Joined: Fri Nov 20, 2009 1:56 pm
- Location: Bakersfield CA.
Re: Transfer case upgrade
by 4x4freakfe427 on Mon Dec 07, 2009 3:39 pm
[quote="cep62"]You could also get a NP435 with a 205 gear drive out of a '76-'79.
Go with what this guy said mid to late 70's 4 speed and 205 case, but you will have to lengthen the front drive shaft or get the donor one and shorten the rear shaft or get the donor one to. I cant remember if you have to modify the cross member. I am in the prosess of doing this same thing on my 71 f100 shorty.
Go with what this guy said mid to late 70's 4 speed and 205 case, but you will have to lengthen the front drive shaft or get the donor one and shorten the rear shaft or get the donor one to. I cant remember if you have to modify the cross member. I am in the prosess of doing this same thing on my 71 f100 shorty.
67 Highboy with 427FE 79 dana 60 front dana 70 rear 13" of lift 38" swampers. 72 F100 2wd short bed 302 toploader 4speed. 71 F100 shortbed 4x4 rust bucket. 68 F100 2wd long bed parts truck no rust.
-
4x4freakfe427 - New Member
- Posts: 77
- Joined: Sun Sep 30, 2007 11:35 pm
- Location: La Center, Washington
Re: Transfer case upgrade
by Redcap on Mon Dec 07, 2009 9:48 pm
eggman918 wrote:Dana 24, I just rebuilt mine at 750,000 miles, I have nothing bad to say about a 24, but they are getting hard to find. However if you have over 450 hp it would be worth finding a NP205.MY truck has a stout 390 and lives in 4WD . Oh well free advice...... Good luck
-
Redcap - 100% FORDified!
- Posts: 2033
- Joined: Mon Dec 20, 2004 11:29 pm
- Location: Washington, Centralia
11 posts • Page 1 of 1
[ Previous topic | Next topic ]
Who is online
Users browsing this forum: No registered users and 2 guests
|
Be sure to visit our sister site! |
